S10s in the Iron Butt Rally!

Don in Lodi

Well-Known Member
Founding Member
2012 Site Supporter
2013 Site Supporter
2014 Site Supporter
Joined
Feb 1, 2011
Messages
5,780
Location
Lodi Kalifornia
To give up your bike for a stranger... dunno about that one. A rim, sure, a whole bike? I don't think he'll make the check point now.
 
Last edited:
B

ballisticexchris

Guest
I was looking at some of the pics and some of those bikes and some of those riders do not look well prepped at all. Eating greasy, slimy heart popper sandwiches, wearing backpacks, bald tires and new tire changes in parking lots at checkpoint one? How about start with a fresh tire for a 10,000 mile ride, pack healthy food for the ride, and ditch the backpack. Apparently prepping is the exception rather than the rule for this event.
 

EricV

Riding, farkling, riding...
2011 Site Supporter
2012 Site Supporter
2013 Site Supporter
2014 Site Supporter
Joined
May 22, 2011
Messages
8,227
Location
Tupelo, MS
Some of you don't appreciate the scale of this event, the roads and temps involved. Or the miles being ridden. Every rider started with fresh tires. The roads in some of these areas are very coarse and high ambient temps don't help tire wear either. Its unlikely anyone had a bald tire at the checkpoint. There is a choice of changing the rear tire early so you have enough tread for the rest of the rally. Most high mile riders will need a tire change, (unless they are running a CT). You're either going to do it at the first or second checkpoint. I did mine at the second in '13, knowing I would have enough tread to finish and not having to worry about riding the last 10% of the rally against a ticking clock, with the last 10% of my rear tire! In the clarity of hindsight, knowing what route I chose, I could have ridden the entire rally on one set of tires. You don't know where you're going until you get the next rally pack at the checkpoint(s)

You eat what you can grab or is provided at checkpoints. Every year is different. I got spaghetti and meatballs with some green salad at one checkpoint. Cold sandwich at another. Pack healthy food? Some do a lot more of that than you may think. But you don't decide, "Oh, I think I'll stop for a salad for lunch today" when every minute is on the clock in a timed event. Minutes you may really, really need later. You grab what ever you can at a gas stop or other stop you're doing anyway. Virtually none of the riders will stop just to eat. That's a wasted stop.

Those likely aren't backpacks, but hydration packs. I'm personally not a fan of wearing your water, but some are. Considering some of the bonuses had significant hikes involved, those riders may have had an edge there.

Chris Purney, the S10 rider that has a totaled bike, is getting a loaner FJR to ride. Likely rally prepped as well, from another IBR Vet. In this community, (LD riding and Endurance Rallys specifically),a lot of us are known to each other, and a lot of us know each other as well. In this case, the rider loaning the bike knows Chris. Insurance is something we all have. I've offered my bike to a rally rider at the start of an IBR when he was having mechanical difficulties. That rider was capable of a top ten finish, (I'm not), and I knew he would be riding my bike harder than I would have if he took it as a loaner. I still offered it. Better to ride on a loaner bike than drop out because your bike has mechanical difficulties. He ended up sorting his problems and rode his own bike w/o issues.

To add to the mix, riders found out at Kennewick that the second checkpoint is no longer a checkpoint. It's just a bonus location worth XXX , (XXXX?), points. Completely optional. They just need to get to the finish in SC. That changes the dynamic hugely. Suddenly those riders that changed their tires the night before are ahead of the game. They have enough tire left to get to the finish, no matter where they go. The riders that planned a tire change at the second checkpoint are left hanging. Now, if they come back to get that tire, it will be on the clock while doing the tire change and limits them from skipping a return to Kennewick.

Riders have all the bonuses left in the rally at this point. That's why planning took longer than usual in Kennewick. They just got a bomb dropped on them and were planning for the following 7.5 days instead of the expected 2.5 days.
 

EricV

Riding, farkling, riding...
2011 Site Supporter
2012 Site Supporter
2013 Site Supporter
2014 Site Supporter
Joined
May 22, 2011
Messages
8,227
Location
Tupelo, MS
One more thing about what riders looked like at the checkpoint. How toasty would you look after riding 4000+ miles in 3.5 days, and knowing you still have 7.5 days left? :rolleyes:
 

Rustykfd

Member
Joined
May 8, 2012
Messages
62
Location
SE WA
Thanks Eric for all the thorough reply’s.

This community is like very few others. I’m not surprised at all that Chris is on a loaner bike, if I were a little closer, he’d be on mine.

I’m the guy with the tire machine and I was at cp1 just in case someone needed tires, there were a few swaps, I expect to be very busy today.

I also rode and finished in 13, same as Eric. I choose to swap tires at cp1 and reduce stress at cp2. I lived for 11 days on Ensure, shooting to eat something solid once a day and drinking Ensure every time I noticed a niggle of hunger.

Everyone has their own plan.


Sent from my iPhone using Tapatalk
 

EricV

Riding, farkling, riding...
2011 Site Supporter
2012 Site Supporter
2013 Site Supporter
2014 Site Supporter
Joined
May 22, 2011
Messages
8,227
Location
Tupelo, MS
Not that I am aware of. Dan chose not to ride the rally this year since he wanted to do it on his own bike. To the best of my knowledge he rode a borrowed bike home to get his truck/trailer, then delivered the bike back to the owner's home, then was heading to Greenville to pick up his bike, presumably not repaired. I would guess he's going to have his local shop look at it then.
 

Cycledude

Well-Known Member
Joined
Jan 29, 2016
Messages
3,997
Location
Rib lake wi
Have we learned the outcome of the S10 with the no start issue and metal shavings in the oil?
It would also be interesting to know what oil those metal shavings were actually in, was it engine oil or final drive oil.

The no start issue is all to common on the first generation Tenere’s, it happened to my 2013 twice in 50,000 miles but luckily both times were at home in my garage. No one seems to be able to prove exactly what causes it. Supposedly the no start issue doesn’t happen to the 2014 and newer Tenere’s, I now have 12,000 miles on my 2018 and thankfully it’s never happened, in fact I believe it always starts slightly better than my 2013 ever did so Yamaha must have figured out something and fixed it.
 
Last edited:

EricV

Riding, farkling, riding...
2011 Site Supporter
2012 Site Supporter
2013 Site Supporter
2014 Site Supporter
Joined
May 22, 2011
Messages
8,227
Location
Tupelo, MS
My understanding is that there were aluminum shavings in the engine oil. No start is also a reaction to the cam chain slipping. BTDT, but aside from a bent valve and dinged piston, I had no shavings in my oil. Though rare, there have been a couple of clutch basket failures resulting in aluminum shavings in the engine oil. The cam chain guides are plastic, so a CCT failure seems like it would not be cause for metal in the oil.

I suspect the changes to the pistons/rings in the Gen II bikes helps avoid the wash down effect during a flooded engine and results in them being less prone to the classic 'hard start'. The other aspect is that we're simply more aware of how to deal with it and avoid it now too.
 

Rustykfd

Member
Joined
May 8, 2012
Messages
62
Location
SE WA
Tenere rider needing help had a rally ready FJR in route in little more than an hour. He will presumably make Kennewick.


Sent from my iPad using Tapatalk
 

EricV

Riding, farkling, riding...
2011 Site Supporter
2012 Site Supporter
2013 Site Supporter
2014 Site Supporter
Joined
May 22, 2011
Messages
8,227
Location
Tupelo, MS
He's moving already. No checkpoint in Kennewick, only a bonus now. Any idea of the hours of the bonus? Or no time restriction now?
 
B

ballisticexchris

Guest
Hi there Eric, I will have to admit I don't have a clue what it would be like to ride over 10,000 miles in 11 days. The tire thing has me scratching my head though? I'm sure there are plenty of tires out there that will go well over 10,000 miles. Are some of the guys starting out with used tires? My Beta was prepped with new tires, pulled apart and inspected clutch, tore down bike and inspected chassis, checked all nuts bolts, new brakes, etc. and I only did the baby 1000 mile run.

This ride actually intrigues me. It looks to be brutal. But I think if a guy/gal just wants to finish and not worry about the bonus points, it's doable if one was to train and prep bike well. I bet chasing after the ever changing bonus points is what bites people in the butt.
 

EricV

Riding, farkling, riding...
2011 Site Supporter
2012 Site Supporter
2013 Site Supporter
2014 Site Supporter
Joined
May 22, 2011
Messages
8,227
Location
Tupelo, MS
Hi there Eric, I will have to admit I don't have a clue what it would be like to ride over 10,000 miles in 11 days. The tire thing has me scratching my head though? I'm sure there are plenty of tires out there that will go well over 10,000 miles. Are some of the guys starting out with used tires? My Beta was prepped with new tires, pulled apart and inspected clutch, tore down bike and inspected chassis, checked all nuts bolts, new brakes, etc. and I only did the baby 1000 mile run.

This ride actually intrigues me. It looks to be brutal. But I think if a guy/gal just wants to finish and not worry about the bonus points, it's doable if one was to train and prep bike well. I bet chasing after the ever changing bonus points is what bites people in the butt.
The big bikes have a hard time finding rear tires that last 10k. Again, no one is starting with used tires. There were a few riders that had perhaps 120 miles or less, simply from riding to the start from relatively close home bases. Virtually everyone got tire changes done at the start city, rode the odo check, (~40 miles), and maybe ran a couple of local errands before the start.

Very, Very few tires will last 10k miles under rally conditions with a rally prepped bike weighing in at 600-1000+ lbs. Especially running in unknown rally conditions, on many back roads in high ambient heat. I could not find ONE rear tire that consistently lasted over 10k miles back in 2008. So I tested and explored the Darkside and became the founding father to FJR Darksiding. 40k miles from a tire that had better traction and better slow speed handling, and was consistent in it's handling for the entire life of the tire.

Front tires on big ADV bikes don't wear nearly as fast. Most are not worried about the front tires. Even my FJR gave me much more front tire life than rear, with a few exceptions. Me880R tires barely gave me 10k and both wore out at the same time and they really sucked in the rain. And I had to run a non-standard size on the rear since the correct size was not available. Some tire brands will go 2 to 1 rear tires wearing faster than the front. This is why some will run a TKC-80 on the front for better traction and not worry about the mileage. I know lots of people that can get 10k from the front TKC-80, but none that can get much better than 4k from the rear. The 1190 rider was running K60 Scouts. He normally got more than 10k from them on his previous GS. I got 12k consistently on my Super Ten, but not in rally mode. In rally mode I changed the rear at checkpoint two even though I was running K60 scouts. Both of these tires are bias ply. It would have been really close for the original K60 I started with to finish the entire rally. I didn't want to take the chance. I suspect the 1190 rider suffered from back roads, heavier load, heat and more Hp than he was used to on the old oil head GS. All those factors contributing to shorter tire life.

Your beta weighs what? 300 lbs? It's not in the same class as full size sport touring, adv touring or full on touring bikes. Sure, the guy on the KLR might make the whole rally on one set. I think the Versys 300 guy may have even planned a tire change. He finished the rally on a stock Ninja 250 one year and did a bunch of cert rides on a NS-125. He likes small, light, minimalist bikes. He packs light for an 11 day ride too. Perhaps that was why he had the backpack, though it had 2-4 liters of water it in too.

The 2 up couple on a Super Ten was running Anakee 3 tires. They ran one set for 2017 and had lots of heat too, but different areas of the country and more major roads. They suffered a blow out, likely due to some road debris and not an actual failure of the tire or wheel, but possibly due to high heat and the weight of a 2 up loaded bike. We may never know. They were planning on running the rally with one set of tires.

One rider, who's won this rally twice and ridden it more times, went thru his tire(s) faster than expected and changed at the first checkpoint. If anyone would know their 'normal' rally tire wear, it would be him. Miscalculation on the kinds of roads they went on during leg one, and the heat the regions they rode in had.

Virtually no radial tire lasts 10k any more on big bikes. Some will, on some bikes, under average conditions. The IBR is not average. You don't know where you will be riding until the night before you leave. And that's just the first leg. At the first checkpoint the riders this year got the bonus pack for the rest of the rally. That's unusual. It's been done, but not since around 2001. The more back roads you ride, the faster your tires will wear. they aren't maintained as well as major roads.

Although the IBR slogan is 11 days, 11,000 miles, riders will ride from 9k to 15k or more. The higher mile riders rarely win. Efficiency usually wins the rally, along with some brute force miles. Meaning that a group of riders of equal or near equal efficiency will be in the top ten, and the winner will probably have ridden to many of the same bonus locations, but put in a few more miles and gotten another note worthy bonus. Others will have ridden more, but scored less.

Mileage does not make you a finisher. Nor a winner. Points do. There is a minimum number of points required to earn finisher status. Above that are bronze level, silver & gold. What challenges riders is planing a route they can ride that gets as many points as possible. What we've see so far is people making mistakes and losing points due to paperwork errors or simply biting off more than they can ride, then getting stuck just hammering back to the checkpoint on big roads with no time to collect any bonuses on the return leg of their ride.

A Good Plan™ will have base goals for the bonuses you want to collect on a route with mileage you believe you can do, with a buffer for the unknown. You will plan in what bonuses you will toss out if you get behind. Preferably low point bonuses, so you can still get the high point or medium point bonuses. You will have a spot, (or spots), in your route that are your benchmarks for when to cut things out, or add things in if you are doing better than expected on time and miles. And you'll have already identified what bonus locations you will add, should you be up on time when you hit your benchmarks.

Plan the ride, ride the plan. Sometimes it is just that simple. But often, the plan goes to shit, so you re-plan and attempt to ride that new plan. Repeat as required. Over 11 days there are a lot of variables. Flooding, snow storms, fires, road closures, typos in the rally pack, locked gates, etc.

What looks like a great shortcut, and Garmin routes you down, turns into a sandy two track with a locked gate you can't get around, within sight of the Hwy you were heading to... And it's 5 miles back that crappy road to get to pavement again so you can ride the 40 miles around to get to the Hwy again. You just lost two hours. Now the bonus you were heading to will be closed before you get there. Do you get a hotel and wait for morning? Re-plan, skipping that high point bonus that was the key to your plan and try to find equal points elsewhere with a new route? Or??

It's a traveling salesman problem, with a lot more twists. Most efficient way to get to all the stops you need to make, but logistically only the best stops with the highest return. Paying attention to the time restrictions of each bonus, if they exist, the realities of the required documentation and your own physical limits.

One rider called and said they were having a very hard time getting a good photo of Old Faithful geyser at 2am since they didn't have enough light to get the picture. It's not lighted like a Las Vegas fountain at night and it's in the middle of a very dark area inside a National Park. No, you can't just hit your spot and get the points, the bonus requires a picture of your rally flag, and the geyser, (and maybe while it's spouting for all I know). Put your big girl panties on and find a solution or wait until daylight.
 

EricV

Riding, farkling, riding...
2011 Site Supporter
2012 Site Supporter
2013 Site Supporter
2014 Site Supporter
Joined
May 22, 2011
Messages
8,227
Location
Tupelo, MS
Chris Purney just got in to the Kennewick bonus. Unconfirmed word is that there is a 8pm cut off for riders to meet. Still not sure if this is a mandatory bonus for riders not headed to AK. Daily report alluded to two choices that allowed skipping the Kennewick "checkpoint" then other info has surfaced that while it's not a checkpoint, it may still be a mandatory bonus with a time restriction.
 

EricV

Riding, farkling, riding...
2011 Site Supporter
2012 Site Supporter
2013 Site Supporter
2014 Site Supporter
Joined
May 22, 2011
Messages
8,227
Location
Tupelo, MS
Looks like someone is heading for Tuk!
If they are, it's unlikely they will make it to Greenville on time. They may have just figured out they are DNF either way. Not making the bonus that allowed you to skip CP 2/mandatory bonus is DNF. Time barred is DNF.
 
Top